Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (2024)

Advertisem*nts

Fuse box diagram (fuse layout), location, and assignment of fuses and relays Jeep Wrangler TJ (1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006).

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (1)

Checking and Replacing Fuses

A fuse is an element for protecting the electrical system. A fuse will trip (i.e. it will blow) in the event of a failure or improper interventions in the electrical system.

If an electrical device is not working, check whether the respective fuse is blown. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Check those fuses first that protect the failed component, but check all the fuses before deciding that a blown fuse is not the cause. Replace any blown fuses with another with the same amperage (same color) and check the component’s operation.

Notice

  • Before changing a fuse, check the ignition key has been removed and that all the other electric devices have been turned off/disabled.
  • Never replace a broken fuse with anything other than a new fuse. Always use a fuse of the same color.
  • Never change a fuse with another amperage. This can cause damage to the electrical system and fire.
  • If the fuse blows again, have the vehicle inspected at a qualified service center.

Passenger Compartment Fuse Box

The fuse panel is located behind the glove box.

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (2)

To access the fuse panel the glove box must be removed. It is removed by slipping the glove box strap off the hook and letting the door roll down off its hinges.

To reinstall, position the glove box door at an 8 o’clock orientation, engage the hinge hook formations on the lower edge of the glove box door with the hinge pins on the lower edge of the instrument panel. Tilt the upper edge of the glove box door upward toward the instrument panel enough to reattach the glove box strap to the door. Rotate glove box door to the closed position. Open and close to insure proper installation.

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (3)

AProtected Component
120Headlamp Switch (Multi-Function Switch), Sentry Key Immobilizer Module
220Brake Lamp Switch
3101999-2002:"PRNDL" Lamp, Front Fog Lamp Switch, Radio, Rear Window Defogger Switch (Hard Top), A/C Heater Control, Rear Wiper/Washer Switch (Hard Top), Instrument Cluster, Rear Fog Lamp Switch, Headlamp Switch
202003-2006:Subwoofer (2003-2006), Radio Choke and Relay (2002)
201997-1998:Fog Lamp Relay №1
410Driver Door Ajar Switch, Passanger Door Ajar Switch, Fog Lamp Relay № 1, Fog Lamp Relay № 2, Rear Fog Lamp Relay
510Airbag Control Module
620Rear Wiper Motor (Hard Top), Rear Wiper/Washer Switch (Hard Top)
710Park/Neutral Position (PNP) Switch (Automatic Transmission), Back-Up Lamp Switch (Manual Transmission), Controller Antilock Brake (ABS), Air Conditioner Compressor Clutch Relay, Rear Window Defogger Relay, ABS Relay
8101999-2006:A/C Heater Control, HVAC Unit, Blower Motor Relay, Blend Door Actuator
201997-1998:A/C Heater Control
910Airbag Control Module, Passenger Airbag On/Off Switch
1010Brake Shift Interlock Solenoid, Instrument Cluster, Compass/Temperature Mirror
11101999-2006:Daytime Running Lamp Module, Torque Converter Clutch Solenoid, Duty Cycle EVAP/Purge Solenoid, Air Conditioner Compressor Clutch Relay
101997-1998:Daytime Running Lamp Module, Torque Converter Clutch Solenoid, Duty Cycle EVAP/Purge Solenoid, Air Conditioner Compressor Clutch Relay, Immobilizer Module, EVAP Leak Detection Pump, Powertrain Control Mudele, Automatic Shut Down Relay, Fuel Pump Relay, Rear Window Defogger Relay
12101999-2006:Sentry Key Immobilizer Module, Fuel Pump Relay, Automatic Shut Down Relay, Powertrain Control Module, Oxygen Sensor Downstream Heater Relay, Oxygen Sensor Upstream Heater Relay
101997-1998:"PRNDL" Lamp, Front Fog Lamp Switch, Radio, Rear Window Defogger Switch (Hard Top), A/C Heater Control, Rear Wiper/Washer Switch (Hard Top), Instrument Cluster, Rear Fog Lamp Switch
1310Turn Signal/Hazard Switch (Multi-Function Switch), Passenger Airbag On/Off Switch (1997-1998)
14201997-1999:Windshield Wiper Switch, Windshield Wiper Motor
252000-2002:Windshield Wiper Switch, Windshield Wiper Motor
102003-2006:Radio
15101997-2002:Radio
102003-2006:Rear Window Defogger Switch (Hard Top)
1610Headlamp Leveling Motor, Headlamp Leveling Switch, Rear Fog Lamp Relay
17101997-2002:Rear Window Defogger Switch (Hard Top)
252003-2006:Windshield Wiper Motor, Windshield Wiper Switch (Multi-Function Switch)
18151997-2002:Unswitched Auxiliary Power
202003-2006:Cigar Lighter/Power Outlet, Switched Auxiliary Power
19201997-2002:Cigar Lighter/Power Outlet, Switched Auxiliary Power
2020Engine Starter Motor Relay, Clutch Pedal Position Switch (Manual Transmission)

Advertisem*nts

Engine Compartment Fuse Box

The electrical power distribution center is located in the engine compartment near the battery.

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (4)

This power center houses plug-in “Cartridge” fuses, ISO relays, and Mini (Micro) fuses. A label inside the latching cover of the center identifies each component for ease of replacement, if necessary.

Diagram (1997-1998)

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (5)

AProtected Component
240Ignition Switch (Fuse (Passenger Compartment): "5", "6", "7", "8", "20"), Engine Starter Motor Relay, Clutch Pedal Position Switch (Manual Transmission)
330Ignition Switch (Cigar Lighter/Accessory Relay, Fuse (Passenger Compartment): "9", "10", "11", "13", "14", "15")
440Fuse Block (Fuse (Passenger Compartment): "1", "2", "3")
540Cigar Lighter/Accessory Relay (Fuse (Passenger Compartment): "19"), Fuse (Passenger Compartment): "18"
630Automatic Shut Down Relay, Powertrain Control Module
7--
8--
920Turn Signal/Hazard Switch
1030Headlamp Switch
1140Blower Motor Relay
12--
1330ABS Relay
1440ABS Pump Motor Relay
1540Rear Window Defogger Relay
1620Fuel Pump Relay
1710Dome Lamp, Instrument Cluster, Data Link Connector, Radio, Courtesy Lamp, Underhood Lamp, Sound Bar Dome Lamp
1810ABS Pump Motor Relay
1910Air Conditioner Compressor Clutch Relay
2020Horn Relay
2120Ignition Coil, Fuel Injector, Oxygen Sensor
Relay
R1Fuel Pump
R2-
R3Automatic Shut Down
R4Air Conditioner Compressor Clutch
R5Horn
R6ABS
R7-
R8ABS Pump Motor
R9Engine Starter Motor
R10Rear Window Defogger

Advertisem*nts

Diagram (1999)

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (6)

AProtected Component
240Ignition Switch (Fuse (Passenger Compartment): "5", "6", "7", "8"), Engine Starter Motor Relay
330Ignition Switch (Cigar Lighter/Accessory Relay, Fuse (Passenger Compartment): "9", "10", "11", "12", "13", "14", "15", "20")
440Fuse Block (Fuse (Passenger Compartment): "1", "2")
540Cigar Lighter/Accessory Relay (Fuse (Passenger Compartment): "19"), Fuse (Passenger Compartment): "18"
630Automatic Shut Down Relay, Powertrain Control Module
7--
8--
920Turn Signal/Hazard Switch
1030Headlamp Switch
1140HVAC Unit
12--
1330ABS Relay
1440ABS Pump Motor Relay
1540Rear Window Defogger Relay
1610Air Conditioner Compressor Clutch Relay
1720Horn Relay
1820Fuel Injector, Ignition Coi (2.5 L)
1920Fuel Pump Relay
2010Underhood Lamp, Left Courtesy Lamp, Right Courtesy Lamp, Radio, Data Link Connector, Dome Lamp (Hard Top), Sound Bar Dome Lamp (4 Speaker System),
2110ABS Pump Motor Relay
22--
23--
24--
2520Fog Lamp Relay №1
26--
2710Leak Detection Pump, Oxygen Sensor
Relay
R1Automatic Shut Down
R2Air Conditioner Compressor Clutch
R3Horn
R4Fuel Pump
R5ABS
R6ABS Pump Motor
R7Engine Starter Motor
R8Rear Window Defogger

Diagram (2000-2006)

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (7)

AProtected Component
140Blower Motor Relay
240Rear Window Defogger Relay
340Fuse (Passenger Compartment): "1", "2", "3"
4402.4L:High Speed Radiator Fan, Low Speed Radiator Fan
5202003-2006:Transmission Control Relay
6302003-2006:Engine Starter Motor Relay, Ignition Switch (Fuse (Passenger Compartment): "5", "6", "7", "8")
402000-2001:ABS Pump Motor Relay
402002:Engine Starter Motor Relay, Ignition Switch (Fuse (Passenger Compartment): "5", "6", "7", "8")
7302000-2001:ABS Relay
202002:Multi-Function Switch
8402002-2006:ABS
402000-2001:Engine Starter Motor Relay, Ignition Switch (Fuse (Passenger Compartment): "5", "6", "7", "8")
9302000-2004:Automatic Shut Down Relay, Powertrain Control Module
202005-2006:Automatic Shut Down Relay, Powertrain Control Module
10402002-2006:Circuit Breaker
302000-2001:Headlamp Switch
11202000-2001:Turn Signal/Hazard Switch
1230ABS
1340Ignition Switch (Fuse (Passenger Compartment): "17", "18", "19")
14302000-2001:Ignition Switch (Cigar Lighter/Accessory Relay, Fuse (Passenger Compartment): "9", "10", "11", "12", "13", "14", "15", "22"), Clutch Pedal Position Switch (Manual Transmission)
302002:Ignition Switch (Fuse (Passenger Compartment): "9", "10", "11", "12", "13", "14", "15", "20"), Clutch Pedal Position Switch (Manual Transmission)
15502003-2006:Fuse: "26"
402000-2001:Cigar Lighter/Accessory Relay (Fuse (Passenger Compartment): "19"), Fuse (Passenger Compartment): "18"
502002:Fuse: "24"
16152002-2004:Oxygen Sensor Downstream Heater Relay
102000-2001:Oxygen Sensor
17202003-2006:Power Outlet
202000-2001:Oxygen Sensor Downstream Heater Relay, Oxygen Sensor Upstream Heater Relay
1820Horn Relay
1920Multi-Function Switch (Front Fog Lamps)
20152003-2006:Radio
2110Air Conditioner Compressor Clutch Relay
22202003-2006:Ignition Switch (Fuse (Passenger Compartment): "9", "10", "11", "12", "13", "14", "22"), Clutch Pedal Position Switch (Manual Transmission)
2320Fuel Pump Relay
24202003-2006:Rear Locker Relay (Off-road Package), Front Locker (Off-road Package)
102002:Dome Lamp, Instrument Cluster, Data Link Connector, Radio, Courtesy Lamp, Underhood Lamp, Sound Bar Dome Lamp
25102000-2001:Dome Lamp, Instrument Cluster, Data Link Connector, Radio, Courtesy Lamp, Underhood Lamp, Sound Bar Dome Lamp
26102003-2006:Dome Lamp, Instrument Cluster, Data Link Connector, Axle Lock Switch (Off-road Package), Courtesy Lamp, Compass/Temperature Mirror, Underhood Lamp
202000-2002:Ignition Coil, Fuel Injector
27202003-2006:Multi-Function Switch
28202003-2006:Automatic Shut Down Relay, Ignition Coil, Fuel Injector, Coil Capacitor
102000-2001:ABS
Relay
R1Automatic Shut Down
R2Air Conditioner Compressor Clutch
R32003-2006:Transmission Control
R4Engine Starter Motor
R5ABS
R62000-2004:Oxygen Sensor Downstream Heater
R72002-2006:Fog Lamp
2000-2001:Oxygen Sensor Upstream Heater
R8Horn
R9Fuel Pump
R10Rear Window Defogger
R112003-2006:Front Locker (Off-road Package)
2005-2006:High Speed Radiator Fan (2.4 L PowerTech)
R122003-2006:Rear Locker (Off-road Package)
2005-2006:Low Speed Radiator Fan (2.4 L PowerTech)
2000-2001:ABS

Advertisem*nts

Jeep Wrangler TJ (1997-2006) Fuse Diagram • FuseCheck.com (2024)
Top Articles
Latest Posts
Article information

Author: Neely Ledner

Last Updated:

Views: 6389

Rating: 4.1 / 5 (62 voted)

Reviews: 85% of readers found this page helpful

Author information

Name: Neely Ledner

Birthday: 1998-06-09

Address: 443 Barrows Terrace, New Jodyberg, CO 57462-5329

Phone: +2433516856029

Job: Central Legal Facilitator

Hobby: Backpacking, Jogging, Magic, Driving, Macrame, Embroidery, Foraging

Introduction: My name is Neely Ledner, I am a bright, determined, beautiful, adventurous, adventurous, spotless, calm person who loves writing and wants to share my knowledge and understanding with you.